MODEL 60010-2 SERIES - 5 Pages

Add to MyDirectIndustry favorites
MODEL 60010-2 SERIES

Catalog excerpts

a xylem brand REMOTE CONTROL SEARCHLIGHT FEATURES • Two High Output Sealed Beam Lamps • Sleek Design • Rugged Construction • Full 360° Rotation • Remote Control and 25 ft. Cable Included • Tough Polyurethane Finish SPECIFICATIONS Voltage: 12 Vdc and 24 Vdc Elevation Angle Model 60010-2 Series (degrees): Housing Material: Candle Power: Up: 30°, Down: 30° Thermoset Plastic 200,000 Model Bulb Weight Standard Number Voltage Amps Type lb (kg) Carton INSTALLATION INSTRUCTIONS LIGHT MOUNTING Select a location for the light which will allow clear beam projection forward and as far aft as possible. Searchlight base should be mounted on a level, flat surface. A mounting block between the searchlight base and mounting surface can be used. The block should be contoured to fit the deck so the searchlight base is level. See mounting template attached for plug and cable required clearance. 1. Mount light with front of base towards the direction of most intended use (front of circular base is marked "front") with gasket under light base. 2. Feed wire through hole and secure light in place. NOTE: cable connectors are provided for easy wiring connections. Mounting hardware is provided: 4 1/4-20 x 2" (6.5mm x 50mm) bolts 4 flatwashers CONTROL MOUNTING Choose a location for the main control near the helm which will allow convenient operation. Control may be mounted on vertical, horizontal, or inclined panel. 1. Route powerleads (supplied by customer) from the voltage source to control. NOTE: Wiring must be 16 gauge with a maximum run of 15 feet. 2. Crimp terminals (supplied) onto the power leads, NOTE: larger terminal is crimped to positive lead, smaller terminal is crimped to negative lead. 3. Insert wiring cable thru back of hole and plug into control. 4. Use bedding compound or sealant to waterproof control. 5. Secure control with self-tapping screws provided.

 Open the catalog to page 1

OPTIONAL SECONDARY CONTROL MOUNTING If an additional control station is desired use control kit numbers 43670-0004 (12 volt) or 18753-0335 (24 volt). Mount secondary control in same manner as main control. Mount station selector panel near the main control (flybridge or lower). CIRCUIT PROTECTION Two (2) automotive blade type fuses are included in the control. One (10 amp) protects the bulb circuit, the other (3 amp) protects the motor circuit. In the event that it should be necessary to replace a fuse simply pull off the protective cover and slide the fuse out. 1. Cut a 2" x 1-3/8" (51mm x...

 Open the catalog to page 2

Upper Housing ower Housing Ease with Gasket Lens with Gasket Eulb (2 Req'd) Eulb Housing Cable Assembly Motor Kit Vertical (Upper) Motor Kit Horizontal (Lower) Drive Arm/Gear Eulb Clip Kit Screws DUAL STATION KIT BULB REPLACEMENT REFERENCE Model Kit Model No. Bulb *NOTE: A 25' wiring cable is provided with each light. Additional lengths may be ordered. Duel station kits require additional cables (see wiring diagram). Order cable length required from table below. ACCESSORY CABLE LISTING Part Number Description 10' Cable Assembly 15' Cable Assembly 25' Cable Assembly 35' Cable Assembly 50'...

 Open the catalog to page 3

REMOTE CONTROL MOUNTING DIMENSIONS STATION SELECTOR PANEL DRAWING WIRING DIAGRAM SINGLE CONTROL WIRING DIAGRAM, OPTIONAL SECONDARY REMOTE CONTROL SECONDARY CONTROL KIT NO. 43670-0004 12V; 18753-0335 24V 12 VOLT POWER INPUT LEADS SUPPLIED BY CUSTOMER (16 GA.) SECONDARY CONTROL CABLE MUST BE ACQUIRED SEPARATELY (SEE CABLE LISTING) 25' CONTROL CABLE INCLUDED FOR ADDITIONAL CABLES SEE CABLE LISTING CONTROL 12 VOLT POWER INPUT LEADS SUPPLIED BY CUSTOMER (16 GA.) STATION SELECTOR PANEL MAIN CONTROL 12 VOLT POWER INPUT LEADS SUPPLIED BY CUSTOMER (16 GA.) THE PRODUCTS DESCRIBED HEREIN ARE SUBJECT...

 Open the catalog to page 4

MOUNTING HOLE FOR 1/4" (6.5mm) BOLT (EQUALLY SPACED-ON 5-3/4" (146mm) DIA B.C.) MOUNTING TEMPLATE

 Open the catalog to page 5

All Xylem France catalogs and technical brochures

  1. Harmful Algae

    12 Pages