Group: SMC
Catalog excerpts
5 Port Solenoid Valve powe ced 5w 0.5 w 55 1. (Con 0 W) . al: 2 ion vent RoHS tion: p m onsu rc Redu New power [With uit] circ saving ard] [Stand With ght DC li Power consumption is reduced by power saving circuit. Power consumption is decreased by approx. 1/3 by reducing the wattage required to hold the valve in an energized state. (Effective energizing time is over 40 ms at 24 VDC.) Refer to electrical power waveform as shown below. Electrical power waveform with power saving circuit Series VF3000 Built-in full-wave rectifier (AC) Noise reduction Noise is considerably reduced by changing it to DC mode with a full-wave rectifier. Reduced apparent power Conventional: 5.6 VA 1.55 VA Built-in strainer in the pilot valve Unexpected troubles due to foreign matter can be prevented. Note) Be sure to mount an air filter on the inlet side. Applied voltage 24 V Rubber material: HNBR Ozone-resistant specification The pilot valve poppet is made of FKM. 0V Standard 1.55 W Energy saving 0.55 W With power saving circuit 0W 40 ms Strainer New Low wattage specification added VF1000/3000 Power consumption Series VF1000/3000/5000 0.35 W (Without light) 0.4 W (With light) CAT.ES11-99C
Open the catalog to page 1Series VF1000/3000/5000 Model Selection by Operating Conditions q Single Unit Series Sonic conductance C [dm3/(s·bar)] VF1000 Type of actuation Port size Voltage Electrical entry Light/Surge voltage suppressor Manual override 2-position single VF1000 (B)2 0.76 4(A) (EB)3 1 5(EA) (P) VF3000 VF5000 Grommet M5 x 0.8 1/8 (A)4 2(B) (EA)5 1 3(EB) (P) L-type plug connector 2-position double VF1000 VF3000 (B)2 4(A) Non-locking push type Body ported (EB)3 1 5(EA) (P) 4.0 VF3000 VF5000 (A)4 2(B) 1/8 1/4 (EA)5 1 3(EB) (P) 3-position closed center (A)4 VF5000 DC 2(B) With surge voltage suppressor (EA)5...
Open the catalog to page 2Cylinder Speed Chart © Please check the actual conditions with SMC Body Ported Model Selection Program. * With when using steel piping Base Mounted * With ^ when using steel piping
Open the catalog to page 4Cylinder Speed Chart w Use as a guide for selection. Please check the actual conditions with SMC Model Selection Program. Conditions Body Ported Body ported Series CJ2 Series CM2 Series MB, CA2 Series CS1 Tubing x Length VF1120-01 T0604 x 1 m T0806 x 1 m — Speed controller AS3002F-06 AS3002F-08 — Tubing x Length VF3130-02 — AN101-01 Silencer Speed controller T1075 x 1 m AS3002F-06 — AS4002F-10 T0604 x 1 m — — AN110-01 Silencer Tubing x Length VF5120-03 T0604 x 1 m T1075 x 1 m T1209 x 1 m Speed controller AS3002F-06 AS4002F-10 AS4002F-12 AN30-03 Silencer AN302-03 Body Ported [when using SGP...
Open the catalog to page 5Pilot Operated 5 Port Solenoid Valve Series VF1000/3000/5000 Single Unit Body Ported How to Order Valve Body ported VF 3 1 3 0 5 G Note) Only DIN and conduit terminal types are available with AC mode. Refer to the electrical entry for details. 1 01 Series 1 3 5 VF1000 VF3000 VF5000 Bracket Type of actuation 1 2 3 4 5 Nil F N T EA/EB port VF5000 3: Main/Pilot valve common Nil T VF1000 Double type only Standard With power saving circuit (DC only) Note) Be sure to select the power saving circuit type when it is continuously energized for long periods of time. (Refer to page 51 for details.) T...
Open the catalog to page 6Pilot Operated 5 Port Solenoid Valve Body Ported/Single Unit Series VF1000/3000/5000 Specifications Model VF1000 VF3000 VF5000 Fluid Series VF1000 Series VF3000 Series VF5000 Air 0.15 to 0.7 Operating Standard 2-position single/3-position 2-position double 0.1 to 0.7 pressure Highrange 0.15 to 1.0 pressure 2-position single/3-position (MPa) type 2-position double 0.1 to 1.0 Ambient and fluid temperature ( C) –10 to 50 (No freezing) 10 10 5 2-position single/double Max. operating frequency (Hz) — 3 3 3-position Non-locking push type Push-turn locking slotted type Manual override Push-turn...
Open the catalog to page 7Pilot Operated 5 Port Solenoid Valve Body Ported/Single Unit Series VF1000/3000/5000 Construction: Body Ported 2-position single VF1000 Symbol 2-position single VF1000 (B)2 4(A) u wr (B) (A) 2 4 qe (A)4 t w u q e (B) 2 (A) 4 y (EB)3 1 5(EA) (P) VF3000 VF5000 VF3000/5000 t 2(B) 3 1 5 (EB) (P) (EA) (EA)5 1 3(EB) (P) r 5 (EA) 1 (P) 3 (EB) y 2-position double Symbol 2-position single VF1000 (B)2 4(A) u wr t w u q (A) 4 (B) (A) 2 4 q (B) 2 (EB)3 1 5(EA) (P) VF3000 VF5000 (A)4 2(B) 3 1 5 (EB) (P) (EA) t (EA)5 1 3(EB) (P) 5 (EA) r 3-position closed center/exhaust center/pressure center Symbol (A)...
Open the catalog to page 9Series VF1000/3000/5000 How to Order Pilot Valve Assembly (With a gasket and two mounting screws) Caution When only the pilot valve assembly is replaced, it is not possible to change from V211 (Grommet or L/M-type) to V212 (DIN or Conduit type), or vice versa. Valve model: 5 G Z VF Select from the below in accordance with the valve used. 1 Grommet or L/M-type V2 11 5 G Z Light/Surge voltage suppressor Nil Without light/surge voltage suppressor With surge voltage suppressor With light/surge voltage suppressor With surge voltage suppressor (Non-polar) With light/surge voltage suppressor...
Open the catalog to page 10Pilot Operated 5 Port Solenoid Valve Body Ported/Single Unit Series VF1000/3000/5000 Dimensions: Series VF1000/Body Ported 1-M5 (-F) 44.5 11.8 1.7 12 80 (6) (Lead wire length) (45) 17.5 2 x ø5.5 (For mounting) (1.6) 41.5 (16) (26) M5 x 0.8, 1/8 [1(P) port] 1.3 ø2.2 (PE port) 12 35 14.5 6 21.5 M5 x 0.8 [5(EA), 3(EB) port] ) s) ort 5EA 3EB G: Approx. 300 H: Approx. 600 ts np (6) (13 . (D 4) bet istan wee ce np orts ) (Indicator light) 4A 2B ee 80 (Lead wire length) - + (1.6) 41.5 Manual override tw G: Approx. 300 H: Approx. 600 10 4A 2B 26.4 Manual override 11.5 12 6) ce or 6. tan n p is e e...
Open the catalog to page 11Series VF1000/3000/5000 Dimensions: Series VF1000/Body Ported 1/8 [4(A), 2(B) port] Manual override (Lead wire length) 44.5 47.5 124.4 (Lead wire length) 5EA 6 21.5 4A 11.5 G: Approx. 300 H: Approx. 600 (13 betw (Dis .4) een tance port s) (Indicator light) 1-01 (D 6.6 bet istanc ) w por een e ts) 2B 1.7 6 47.5 124.4 G: Approx. 300 H: Approx. 600 (1 12 26.4 4A 2B - + 10 26.4 1.7 .7) (11 nce ta n (Disetwee s) b port M5 x 0.8 [4(A), 2(B) port] Manual override G H Grommet (G) (H): VF1220- (4) 1-M5 1.7 G H 1.7 2-position double Grommet (G) (H): VF1220- M5 x 0.8, 1/8 [1(P) port] 1.3 2 x ø2.2 (PE...
Open the catalog to page 12All SMC PNEUMATIC catalogs and technical brochures
-
SYJ300/500/700 Series
62 Pages
-
Vacuum Unit ZK2 Series
60 Pages
-
Air Cylinder CJ2 Series
117 Pages
-
AS-FS Series
36 Pages
-
IDF series
12 Pages
-
MHL2 Series
24 Pages
-
JCM Serie
18 Pages
-
EX245 Series
12 Pages
-
Pin Cylinder CJP2/CDJP2/CJP
19 Pages
-
5 Port Solenoid Valve VQC
63 Pages
-
5 Port Solenoid Valve VQ
79 Pages
-
SY
268 Pages
-
5-p0979-0980-hep500
2 Pages
-
5-p0977-0978-aep100
2 Pages
-
5-p0966-0971-lmu
5 Pages
-
5-p0960-0966-alb900
6 Pages
-
5-p0956-0960-ald600
5 Pages
-
5-p0948-0950-al800
3 Pages
-
es70-44c-vx2
52 Pages
-
es50-37-kq2
124 Pages
-
ex-pcw
23 Pages
-
1-p2124-2152-ex510
29 Pages
-
1-p2111-2122-ex500
12 Pages
-
1-p2063-2073-ex260
11 Pages
-
4-p0147-0178-msu-mds
32 Pages
-
es20-230b-crb2
59 Pages
-
1-p1869-1878-vp3145
10 Pages
-
VP300/500/700 series
42 Pages
-
1-p1789-1829-vqz100
41 Pages
-
1-p1727-1788-syj300
62 Pages
-
5 Port Solenoid Valve S0700
111 Pages
-
5 Port Solenoid Valve VF
59 Pages
-
5 Port Solenoid Valve SV
127 Pages
-
VH
9 Pages
-
CUJ
41 Pages
-
AL
3 Pages
-
kj mm
9 Pages
-
AQ
4 Pages
-
SY3000/5000-X13
2 Pages
-
Series MB
24 Pages
-
Series LES
23 Pages
-
Series LEFB
16 Pages
-
Series PF3W
28 Pages
-
Series IDG?A/IDG
56 Pages
-
Floating Joint
7 Pages
-
Series IZS40/41/42
32 Pages
-
Series LEY
7 Pages
-
Series VHS
12 Pages
-
Series CY1S
28 Pages
-
SeriesCQ2/CQS/CQ
4 Pages
-
In-line Air Filter
12 Pages
-
Series CQ2/CQS
2 Pages
-
AS series
2 Pages
-
corporate guide
13 Pages
-
ZP
69 Pages
-
ZFA
14 Pages
-
ZA
13 Pages
-
MHF
32 Pages
-
MHZ
68 Pages
-
CRB
44 Pages
-
D
117 Pages
-
RB
23 Pages
-
CEP
44 Pages
-
RSK
30 Pages
-
CLK
51 Pages
-
MK
20 Pages
-
GLJ
65 Pages
-
MGJ
7 Pages
-
Mx
36 Pages
-
MXH
18 Pages
-
My3
56 Pages
-
my1b
20 Pages
-
CC
15 Pages
-
J
14 Pages
-
CQ2
51 Pages
-
standard cylinder
84 Pages
-
VFN
6 Pages
-
SY3000
246 Pages
-
SJ3A6
18 Pages
-
1301/IW
14 Pages
-
CHQ/CHDQ
19 Pages
-
AC
95 Pages
-
HAW
4 Pages
-
HAA
3 Pages
-
ZB
24 Pages
-
CRB2
35 Pages
-
CJ1
5 Pages
-
SYJ
62 Pages
-
SJ
78 Pages