Group: SMC
Catalog excerpts
4 Port Solenoid Valve Cassette Type Manifold SJ2000/3000 Rubber Seal Plug-in cable type manifold is added ! r ecto onn ction C e conn S0700 VQ Additional options are now available. SUP/EXH block assembly with regulator and pressure switch Valve with speed controller ø6 ø4 ø2 Individual wiring manifold An additional type of manual override is now available. Slide locking type ø2 connection is possible. One-touch fitting Vacuum release valve with restrictor Suction and release can be controlled with a single unit.
Open the catalog to page 14 Port Solenoid Valve Cassette Type Manifold Power consumption Manifold uses halogen-free lead wires. 0.15 W ∗ (SJ3000 with power saving circuit) 0.23 W ∗ (SJ2000 with power saving circuit) Note) Refer to page 115 for details. Plug-in cable type manifold Service life of 50 million cycles or more (Based on SMC life test conditions) Connector type (Card edge type) Series SJ2000 and SJ3000 can be mounted together. • Can easily increase or decrease stations and replace valves. • 34 pins connector allows up to 16 stations with double solenoids, 32 stations with single solenoids. Non plug-in...
Open the catalog to page 2PC wiring compliant ∗ Connector type only. D-sub connector SJ SY SY EX180 Integrated-type (for output) serial transmission system ∗ Connector type only. Flat ribbon cable VF VP4 S0700 EX510 Gateway-type serial transmission system ∗ Connector type only. EX180 Integrated-type (for output) serial transmission system∗ EX510 Gateway-type serial transmission system∗ ∗ Connector type only. ∗ Connector type only. CC-Link (32 outputs), DeviceNet (32, 16 outputs) Easy attaching/detaching of the SI unit and wiring by the connector Max. 128 points (Input 64 points/ Output 64 points) All wires can be...
Open the catalog to page 34 Port Solenoid Valve Cassette Type Manifold Regulator block Regulator block This is a regulator block with the same width (10 mm) as the SJ3000. Pressure supplied from the D side is used to reduce pressure in the manifold. The U side valves are all depressurized from the regulator block. Pneumatic circuit (example of regulator block installation) Regulator block Set to 0.2 MPa Note) Reduces supply pressure from the D side of the manifold. Supply pressure from the U side cannot be reduced. Both the pressure gauge mounting position and the method of operating the pressure adjustment screw...
Open the catalog to page 4Series SJ2000/3000 SUP/EXH block assembly with regulator and pressure switch This pressure regulator is intended to adjust the SUP pressure of the manifold. Additionally, pressure switch and pressure gauge can be mounted. SUP/EXH block assembly with regulator and pressure switch Upward handle Valve with speed controller Meter-in: Black Valve with speed controller Meter-out: Silver As a speed controller is built-into this valve, the cylinder speed can be adjusted on the valve side. Two types, meter-in and meter-out, are set. Pneumatic circuit (Installation example of SUP/EXH block assembly...
Open the catalog to page 5Vacuum Release Valve with Restrictor Two spool valves are built-in. Vacuum suction and release can be controlled with a single valve. Slotted locking type Restrictor • Flow rate adjustment of release air • Prevents workpiece blow-off. Plug-in Connector connection Cable connection PS port: Pressure detection port (M5 x 0.8) Filter • Eliminates foreign matter on vacuum and release side. • Replaceable 2(B) Vacuum pad port 1(P) Release pressure port 3/5(E) Vacuum pressure port Wiring variations • D-sub connector • Serial (EX180) • Flat ribbon cable • Serial (EX510) • PC wiring • D-sub connector...
Open the catalog to page 64 Port Solenoid Valve Series SJ2000/3000 Plug-in Connector Type Manifold D-sub Connector/Flat Ribbon Cable/PC Wiring Cable Type Manifold How to Order/Connector Type P.32 Manifold Electrical Wiring/Connector Type, Cable Type P.36 Dimensions/Connector Type, Cable Type P.38 S^ji I PC Wiring System with Power Supply Terminal ^ Manifold Electrical Wiring/Connector Type P.52 EX180 Integrated-type (For Output) Serial Transmission System EX510 Gateway-type Serial Transmission System Manifold Exploded View/Connector Type, Cable Type P.73, 74 How to Increase Manifold Stations/Connector Type, Cable...
Open the catalog to page 7Manifold Variations 4 Port Solenoid Valve Series SJ2000/3000 Individual wiring Serial wiring PC wiring (With power supply terminal) Flat ribbon cable connector Manifold type D-sub connector Vacuum Release Valve with Restrictor Series SJ3A6 Connection method Parallel wiring Connector Type Note 1) SS5J2/3-60 4 port solenoid valve Connector Type Vacuum release valve with restrictor Note 1) A linkage printed circuit board is built-into the individual wiring valve so as to combine with the plug-in type. Note 2) Specify the required specifications in the manifold specification sheet. Note 3) The...
Open the catalog to page 8Series SJ2000/3000 Series SJ3A6 Main valve fluororubber specifications With individual switch With power saving circuit Increase of manifold stations Voltage suppressor Intermediate connector block assembly Valve with speed controller Solenoid valve specifications SUP/EXH block assembly with regulator and pressure switch Regulator block Dual flow fitting Blanking block assembly Different pressure pneumatic circuit diagram/ Block disk assembly Mixed wiring Single/Double Manifold options
Open the catalog to page 94 Port Solenoid Valve Manifold Specifications Flat ribbon cable D-sub connector Serial wiring Individual wiring Connector type/ Cable type Manifold type Connector type/ Cable type ( ) ) Type 60G (Connector type) ( Type 60J (Connector type) Connector type/ Cable type Plug-in, Connector type/Cable type Plug-in, Connector type 1 to 18 stations(Type PG) 1 to 8 stations 1 to 16 stations(Type J, Type G) Connector type: 1 to 24 stations Cable type: 2 to 20 stations D-sub connector Conforming to MIL-C-24308 JIS-X-5101 Applicable connector Internal wiring Flat ribbon cable connector Socket: 26 pins...
Open the catalog to page 10Common Specifications Series Solenoid Valve Specifications Fluid Internal pilot operating pressure range (MPa) 4 position dual 3 port valve 4 position dual 3 port valve 3 position 2 position single, double Non-locking push type Push-turn locking slotted type Internal pilot Main and pilot valve common exhaust External pilot Pilot valve individual exhaust Mounting orientation Impact/ Vibration resistance (m/s2) Manual override (Manual operation) Pilot exhaust method Ambient and fluid temperature (°C) Flat ribbon cable Operating pressure range External pilot 2 position single operating...
Open the catalog to page 11All SMC PNEUMATIC catalogs and technical brochures
-
SYJ300/500/700 Series
62 Pages
-
Vacuum Unit ZK2 Series
60 Pages
-
Air Cylinder CJ2 Series
117 Pages
-
AS-FS Series
36 Pages
-
IDF series
12 Pages
-
MHL2 Series
24 Pages
-
JCM Serie
18 Pages
-
EX245 Series
12 Pages
-
Pin Cylinder CJP2/CDJP2/CJP
19 Pages
-
5 Port Solenoid Valve VQC
63 Pages
-
5 Port Solenoid Valve VQ
79 Pages
-
SY
268 Pages
-
5-p0979-0980-hep500
2 Pages
-
5-p0977-0978-aep100
2 Pages
-
5-p0966-0971-lmu
5 Pages
-
5-p0960-0966-alb900
6 Pages
-
5-p0956-0960-ald600
5 Pages
-
5-p0948-0950-al800
3 Pages
-
es70-44c-vx2
52 Pages
-
es50-37-kq2
124 Pages
-
ex-pcw
23 Pages
-
1-p2124-2152-ex510
29 Pages
-
1-p2111-2122-ex500
12 Pages
-
1-p2063-2073-ex260
11 Pages
-
4-p0147-0178-msu-mds
32 Pages
-
es20-230b-crb2
59 Pages
-
1-p1869-1878-vp3145
10 Pages
-
VP300/500/700 series
42 Pages
-
1-p1789-1829-vqz100
41 Pages
-
1-p1727-1788-syj300
62 Pages
-
5 Port Solenoid Valve S0700
111 Pages
-
5 Port Solenoid Valve VF
59 Pages
-
5 Port Solenoid Valve SV
127 Pages
-
VH
9 Pages
-
CUJ
41 Pages
-
AL
3 Pages
-
kj mm
9 Pages
-
AQ
4 Pages
-
SY3000/5000-X13
2 Pages
-
Series MB
24 Pages
-
Series LES
23 Pages
-
Series LEFB
16 Pages
-
Series PF3W
28 Pages
-
Series IDG?A/IDG
56 Pages
-
Floating Joint
7 Pages
-
Series IZS40/41/42
32 Pages
-
Series LEY
7 Pages
-
Series VHS
12 Pages
-
Series CY1S
28 Pages
-
SeriesCQ2/CQS/CQ
4 Pages
-
In-line Air Filter
12 Pages
-
5 Port Solenoid Valve
60 Pages
-
Series CQ2/CQS
2 Pages
-
AS series
2 Pages
-
corporate guide
13 Pages
-
ZP
69 Pages
-
ZFA
14 Pages
-
ZA
13 Pages
-
MHF
32 Pages
-
MHZ
68 Pages
-
CRB
44 Pages
-
D
117 Pages
-
RB
23 Pages
-
CEP
44 Pages
-
RSK
30 Pages
-
CLK
51 Pages
-
MK
20 Pages
-
GLJ
65 Pages
-
MGJ
7 Pages
-
Mx
36 Pages
-
MXH
18 Pages
-
My3
56 Pages
-
my1b
20 Pages
-
CC
15 Pages
-
J
14 Pages
-
CQ2
51 Pages
-
standard cylinder
84 Pages
-
VFN
6 Pages
-
SY3000
246 Pages
-
SJ3A6
18 Pages
-
1301/IW
14 Pages
-
CHQ/CHDQ
19 Pages
-
AC
95 Pages
-
HAW
4 Pages
-
HAA
3 Pages
-
ZB
24 Pages
-
CRB2
35 Pages
-
CJ1
5 Pages
-
SYJ
62 Pages
-
SJ
78 Pages