Catalog excerpts
Shenzhen Consnant Technology Co., Ltd. 规格确认书 Specification Series 产品系列 Model and Capacity 型号及容量 Customer Name or code 客户名称或代码 File No. 文件编号 File Version 版本号 Issue Date 发行日期
Open the catalog to page 1
Shenzhen Consnant Technology Co., Ltd. AEMDMENT RECORDS (规格变更记录) 版本号 Version Number 变更内容描述 Emendatory content description 发行日期 Issued Date 制作 审核 批准 Prepared Checkup Approved
Open the catalog to page 2
Shenzhen Consnant Technology Co., Ltd. Contents 目录 1． 适用范围 Scope 2． 体系 System ………………………………………………………………………………………3 3． 常规技术参数 General Specifications ……………………………………………………………………3 4． 产品性能测试 Product performance test …………………………………………………………………4 5． 产品贮存及运输 Product Storage and Transportation
Open the catalog to page 3
Shenzhen Consnant Technology Co., Ltd. 1. 适用范围 Scope 本产品规格书适用于深圳创能恒电科技有限公司向客户提供的可充电锂电池产品 72V 150Ah。 This specification is applied to rechargeable Lithium Cell 72V 150Ah produced by Shenzhen Consnant Technology Co., Ltd. 2. 体系 System 可充电锂离子电池 Rechargeable Lithium Ion Battery 3. 常规技术参数 General Specifications 项目 Item 额定容量 Rated Capacity 内阻 internal Impedance 标称电压 Nominal Voltage 充电截止电压 Charging Voltage 充电方法 Charging Method 标准充电制度 Standard Charging Process 在 25° 5 ° 下，以 0.2C 恒流充电至 83.95V,然后恒 C C 压充电到充电电流减小到 0.02C，即充满电。 0.2C (CC) charge to 83.95V, when 83.95V (CV) is reached, charge rate will...
Open the catalog to page 4
Shenzhen Consnant Technology Co., Ltd. 12 13 电池重量(最大值) Battery Weight(MAX) 电池循环寿命 (标准充放电) battery Cycle Life（standard charge & discharge） 放电 Discharge 操作温度 充电 Operating Charge Temperature 贮存 Storage 1 个月内 Within 1 month 贮存温度 3 个月内 Storage Within 3 month temperature 6 个月内 Within 6 month ≤130Kg ≥2500 次 （注:剩余容量≥70% remark: the residual capacity is more than 72% of the first cycle discharge capacity） -20° to 55° C C 0° to 45° C C 10° to 30° C C - 5° ~ +45° C C - 5° ~ +35° C C 0° ~ +35° C C 4. 产品性能测试 Products performance test NO. Test condition and method 荷电性能 Self-discharge Performance 高温放电性能...
Open the catalog to page 5
Shenzhen Consnant Technology Co., Ltd. Heating Test 振动测试 Vibration test 自由跌落测试 Free falling(drop) Test 外部短路测试 External Short-circuiting test 温度循环测试 Temperature Cycling Test 恒定湿热测试 Humidity and heat test 重物冲击测试 Impact test 升到 130±2℃并保温 30 分钟 The temperature of the oven is to be raised at a rate of 5± 2℃/min. to a temperature of 130± 2℃, and remains for 30 minutes at this temperature. 电池在振幅为 0.8 mm （1.6mm）的简谐振动，振 动频率为： 10～55 Hz,扫频速率为:1 Hz/min, X、 Y、 Z 三个方向各振动一次，振动时间为 30min. Let the battery subjected simple harmonic motion with an amplitude of 0.8 mm（1.6mm）total maximum excursion].The...
Open the catalog to page 6
Shenzhen Consnant Technology Co., Ltd. 32mm 的活塞提供，压强为 17.2 MPa，压力为 13 kN 即可停止。 Crush the battery between two flat surfaces ,The force for the crushing is to be applied by a hydraulic ram with a 32 mm diameter piston. The crushing is to be continued until a pressure reading 17.2 MPa is reached on the hydraulic ram, applied force of 13 kN. Crush Test 5. 产品贮存及运输 Product Storage and Transportation 5.1 产品贮存 Product Storage 如电池贮存 6 个月以上，电池须置于温度为 20± 5℃、湿度为 65± 20%RH 的环境中，电池的贮存电压 需保持在 73.6V~83.95V，请每隔 3 个月激活电池一次，具体方法如下:标准充放电后，搁置 5 分钟， 0.2C 充电至 83.95V. If the cell is to be stored for 6 months or...
Open the catalog to page 7
Shenzhen Consnant Technology Co., Ltd. Note(2): Shenzhen Consnant Technology Co., Ltd. will take no responsibility for any accident when the battery is used under other conditions beyond those described in this Document. 声明三： 如有必要深圳创能恒电科技有限公司会以书面形式告之客户有关正确操作使用电池的改进措施。 Note(3): Shenzhen Consnant Technology Co., Ltd. will inform the customer of improvements regarding proper use and handing of the battery in a written form, if it is necessary. 6.1. 充电 Charging 电池必须在 0℃～45℃的环境温度范围内进行充电，充电电流不得超过本标准书中规定的最大充电 电流。充电电压不得超过本标准书中规定的额定电压,83.95V 为充电电压最高极限，充电器的设计 应满足此条件；禁止反向充电，...
Open the catalog to page 8
Shenzhen Consnant Technology Co., Ltd. never be done by the users. 6.3.6. 禁止使用已损坏的电池 Prohibit to use damaged battery 7. 备注 Remarks 若发现此规格书有任何问题，需经双方同意后方可修改。 If any matters concerning the specifications of the battery, it must be mutually agreed before any revision of the specifications are made. 8. 附录 Appendix 8.1. 产品线路图 Product circuit diagram 8.2电池标贴 8.3.Dimensional Drawing 尺寸图纸 8.3.1:Pack 电池组 (充电接口和放电接口按客户指定要求配套) 规格尺寸：MAX 长 1500mm
Open the catalog to page 9
Shenzhen Consnant Technology Co., Ltd. Manufacturer reserve the right to alter or amend the
Open the catalog to page 10All Shenzhen Consnant Technology Co. catalogs and technical brochures
-
Outdoor product collection1 Pages
-
Hybrid Telecom system1 Pages
-
Industrial Online UPS2 Pages
-
High Frequency Online UPS2 Pages
-
Solar Power System1 Pages
-
APF&SVG1 Pages
-
Industrial Online UPS CE1 Pages
-
Product certification2 Pages
-
Inverter certification1 Pages
-
Inverter certification1 Pages
-
SVG -LVD test report61 Pages
-
SVG-EMC test report33 Pages
-
APF-LVD test report39 Pages
-
APF- EMC test report33 Pages
-
SVG CE certificate1 Pages
-
APF CE certificate1 Pages
-
ISO System Certificate6 Pages
-
ODU Telecom Cabinet12 Pages
-
Industrial Online UPS1 Pages
-
Home ESS1 Pages
-
APF/SVG1 Pages
-
Product Collection1 Pages
-
Energy storage batteries1 Pages
-
Lead-acid Battery Series12 Pages
-
Industrial Outdoor UPS(1)3 Pages
-
Rack Mount Online UPS 1-3KVA5 Pages
-
Home ESS SmartCute series4 Pages
-
APF(SVG)10 Pages
-
Consant user manual34 Pages
-
Hybrid Solar Inverter1 Pages
-
Outdoor UPS1 Pages
-
ESS1 Pages
-
Moduar UPS1 Pages
-
ODU system specification11 Pages
-
lithium portable power supply22 Pages
-
Modular online UPS 600KW41 Pages
-
Micro Modular Data Center16 Pages
-
Power Module 50KW14 Pages
-
CE certificate1 Pages
-
outdoor ups CNW1102 Pages
-
electricity online ups2 Pages
