SERVOTOUGH Laser Certification Supplement Manual - 68 Pages

Add to MyDirectIndustry favorites
SERVOTOUGH Laser Certification Supplement Manual

Catalog excerpts

SERVOTOUGH Laser Gas Monitor Part Number: Revision: Language: 02930008A 4 UK English SERVOMEX \ A MEASUREABLE ADVANTAGE

 Open the catalog to page 1

This page intentionally blank

 Open the catalog to page 2

2    EU DECLARATION OF CONFORMITY 5    NORTH AMERICAN APPROVALS (CSA)

 Open the catalog to page 3

SECTION 1 INTRODUCTION The 2900 monitor series has been approved by various authorities for installation in hazardous areas. The certification offered with a specific monitor will depend upon the analyser specification and country of delivery. See the certification labels attached to the analyser for exact approval details. The following information summarises the approvals that have been obtained. This certification manual covers: 1. 02930 Series SERVOTOUGH LaserSP 2. 02940 Series SERVOTOUGH LaserCompact The installer and/or the user of the analyser must be satisfied that the installation...

 Open the catalog to page 5

SECTION 2 EU DECLARATION OF CONFORMITY

 Open the catalog to page 7

This declaration of conformity is issued under the sole responsibility of the manufacturer. Equipment Type:    SERVOTOUGH Laser SP (02930) Series Analysers SERVOTOUGH LaserCompact (02940) Series Analysers Directive    ATEX 2014/34/EU (Applicable to items located in a hazardous area) When used in a Zone 1 Hazardous Area (02930 only): EC Type Examination Certificate:    Baseefal0ATEX0072X, Baseefa; 1180 Harmonised Standards used:    EN 60079-2:2007, EN 60079-26:2007, EN 60079-28:2007 Other Standards used:    EN 60079-0:2009 (See Note) When used in a Zone 2 or Zone 21 Hazardous Area: EC Type...

 Open the catalog to page 9

SECTION 3 ATEX CERTIFICATION Certificate No.:    Baseefa 10ATEX0100X (Gas and Dust) EX2: 2900 series monitor has been certified to: Mains Power Supply Ex nA nC op is IIC T4 Gc [Ex op is IIC T6 Gb] Ex nA nC op is IIC T4 Gc [IIIB T70°C Da] Ex tb IIIB T75°C IP66 Db [Ex op is IIC T6 Gb] Ex tb IIIB T75°C IP66 Db [IIIB T70°C Da] For situations where there is heat gain from the process, the following table may be used to determine the maximum operating ambient temperature and maximum surface temperature for dust of the equipment: Special Conditions of Safe Use: 1. The temperature class of the...

 Open the catalog to page 11

Certificate Number Baseefal 0ATEX01OOX Issued 9 July 2010 Page 1 of 4 EC - TYPE EXAMINATION CERTIFICATEEquipment or Protective System Intended for use in Potentially Explosive Atmospheres Directive 94/9/EC BaseefalOATEXOlOOX 3 EC - Type Examination Certificate Number: 4 Equipment or Protective System:    SERVOTOUGH Laser Crowborough, East Sussex, TN6 3FB 7 This equipment or protective system and any acceptable variation thereto is specified in the schedule to this certificate and the documents therein referred to. 8 Baseefa, Notified Body number 1180, in accordance with Article 9 of the...

 Open the catalog to page 13

Certificate Number Baseefal 0ATEX01OOX Issued 9 July 2010 Page 2 of 4 13    Schedule 14    Certificate Number BaseefalOATEXOlOOX 15 Description of Equipment or Protective System The 02900-Series SERVOTOUGH Laser is an optical instrument based on transmitting infrared laser light from a transmitter to a solid-state detector inside the receiver. The detection principle is called infrared single-line absorption spectroscopy. The 02930 SERVOTOUGH Laser consists of two units which are mounted on opposite sides of the flue stack to be monitored. The transmitter consists of a mains power supply...

 Open the catalog to page 14

24V Powered Rated Voltage: 30Vdc © II 3(2)G    Ex nA nC op is IIC T5 Gc [Ex op is IIC T6 Gb] (-20°C < Ta < +65°C) © II 2(1 )D    Ex tb IIIC T75°C IP66 Db [IIIC T70°C Da] (-20°C < Ta < +65°C) With the option to mark the equipment IIIB in place of IIIC. 16 Report Number GB/BAS/ExTRl 0.0065/00 17 Special Conditions for Safe Use 1. The temperature class and operating ambient temperature range of the equipment is affected by the process flange temperature as detailed in section 15 above. 2. The equipment shall be installed so as to minimise the risk from propagating brush discharges. 18...

 Open the catalog to page 15

Issued 9 July 2010 Page 4 of 4 Number Sheet    Issue These drawings are associated and held with 18/06/10    PCB Block Diagram

 Open the catalog to page 16

Certificate Number Baseefal 0ATEX01OOX/1 Issued 3 February 2011 Page 1 of 2 2    Equipment or Protective System Intended for use in Potentially Explosive Atmospheres Examination Certificate Number: 4    Equipment or Protective System: Baseefal0ATEX0100X/l SERVOTOUGH Laser Servomex Group Limited Crowborough, East Sussex, TN6 3FB 7 This supplementary certificate extends EC - Type Examination Certificate No. Baseefa 10ATEX0100X to apply to equipment or protective systems designed and constructed in accordance with the specification set out in the Schedule of the said certificate but having any...

 Open the catalog to page 17

Issued 3 February 2011 Page 2 of 2 13    Schedule 14    Certificate Number Baseefal0ATEX0100X/l 15 Description of the variation to the Equipment or Protective System Variation 1.1 To permit the use of an alternative Main Board. Variation 1.2 To permit minor mechanical changes to the equipment. 16 Report Number GB/BAS/ExTRl 1.0021/00 17 Special Conditions for Safe Use None additional to those listed previously 18 Essential Health and Safety Requirements Compliance with the Essential Health and Safety Requirements is not affected by this variation. Description Connection Board Alternative...

 Open the catalog to page 18

Certificate Number Baseefal 0ATEX0100X/2 Issued 25 August 2011 Page 1 of 3 SUPPLEMENTARY EC - TYPE EXAMINATION CERTIFICATE Equipment or Protective System Intended for use in Potentially Explosive Atmospheres Directive 94/9/EC 3 Supplementary EC - Type Examination Certificate Number: 4 Equipment or Protective System:    SERVOTOUGH Laser Servomex Group Limited Crowborough, East Sussex, TN6 3FB 7 This supplementary certificate extends EC - Type Examination Certificate No. BaseefalOATEXOlOOX to apply to equipment or protective systems designed and constructed in accordance with the...

 Open the catalog to page 19

All SERVOMEX catalogs and technical brochures

  1. 4900 Multigas

    4 Pages