RK 11-1404 Seal Kit For 900 or 1000 FE, FF, FG, FH and MA Series Fuel Filter/Water Separators Instruction Part Number 11-1405 Rev F This kit contains all necessary seals and O-rings to perform a tear down and rebuild of a 900 or 1000 turbine series fuel filter/water separator. Disassemble unit in the numerical order shown. Inspect all parts for damage and clean them in solvent or fresh diesel fuel only. Ensure all parts, O-ring glands, and sealing surfaces are free of dirt or debris and coat all seals with grease or motor oil prior to reassembly. Reassemble unit in reverse of steps shown. Contact Information Parker Hannifin Corporation Racor Division PO. Box 3208 3400 Finch Road Modesto, CA 95353 phone 800 344 3286 209 521 7860 fax 209 529 3278 [email protected] parker.com/racor The parts list (shown on next page) shows all servicable parts for 900 and 1000 assemblies and the items provided in this kit are identified in black. If you require replacement parts not included in this kit, use kit numbers provided and order from a Racor distributor. Parker Racor ENGINEERING YOUR SUCCESS.

Parts in this kit are listed in black. Kits listed in white can be purchased from a Racor distributor. Go to parker.com/racor for a distributor near you. Part Number 9 RK 30476 (FH, FG>2002) Self-venting Drain Kit Tighten to 30 in. lbs (3.39 Nm) 9a (not sold seperately) Drain Gasket 12b (not sold seperately) Drain Body O-ring 14 RK 15104 Heat Deflector/Drain Fitting Kit

RK 11780 Drain Kit Fits FE, FF, & FG (1993 & Older) RK 15104 Heat Deflector/Drain Fitting Kit Fits All 900/1000MA Assemblies Replacement Instructions Tear down is performed in numerical order shown. Rebuild unit in reverse order, replace old parts with new as applicable. Completely drain the assembly. 1. Remove T-handle and o-ring. 2. Remove lid and lid gasket. On rebuild, lubricate gasket with diesel fuel or motor oil prior to installation. 3. Remove all four capscrews. 4. Remove bowl ring. Metal bowls do not have bowl ring. 5. Remove bowl and bowl gasket. On rebuild, lubricate gasket with diesel...

All products manufactured or distributed by Racor are subject to the following, and only the following, LIMITED EXPRESS WARRANTIES, and no others: For a period of one (1) year from and after the date of purchase of a new Racor product, Racor warrants and guarantees only to the original purchaser-user that such a product shall be free from defects of materials and workmanship in the manufacturing process. The warranty period for pumps and motors is specifically limited to ninety (90) days from date of purchase. A product claimed to be defective must be returned to the place of purchase. Racor,...