FTNON Swirl Bath Washer The combination of special techniques gives an optimal washing result while the product is treated as delicate as possible. Eminently designed for washing and mixing different products, such as sliced vegetables, salads and herbs

Washing The product arrives in a water bath with a calm flow. Water is being injected into the water bath; this creates a screw rotation of the wash water. Thus the product is massaged and dirt comes loose without subjecting the product to large forces. The screw rotation causes a maximum retention time in the washer. Outfeed At the outfeed side of the water tank an accelerated water flow pulls the product out of the washer. Dewatering belt The product is being dewatered on a dewatering belt. After dewatering, the water is fed back to the filter from where it will be re-circulated. Fresh water...

Technical specifications - Fresh water spraying pipe - Filter SBW 062 SBW 063 SBW 064 SBW 093 SBW 094 FRESH WATER SPRAYING PIPE VALVE manual manual manual manual manual SUPPLY FRESH WATER pipe 1” pipe 1” pipe 1” pipe 1” pipe 1” FILTER TYPE static static static static static FILTER OPENING wedge wire 750 pm wedge wire 750 pm wedge wire 750 pm wedge wire 750 pm wedge wire 750 pm Hygiene The swirl bath washer has a very open construction, so that the inner side of the water bath is completely accessible. The swirl bath washer runs itself empty very well, through which little product remains after...

JBT FTNON Swirl Bath Washer filter does not require attention. The filter system is executed as a rotating wedge wire drum through which the water flows. Because of the wedge wire sieve profile, it is almost not possible for dirt to pile up in the filter gaps. The drum turns at a very low speed and dirt is scraped off from the outside. The water is buffered in the pump tank under the filter. TECHNICAL SPECIFICATIONS - ROTATING FILTER TYPE rotating FILTER OPENING wedge wire 750 μm DRIVE Motor gearbox combination 7) Extra fine rotating filter instead of static filter All the recycled water is being...

JBT FTNON Swirl Bath Washer TECHNICAL SPECIFICATIONS – COOLING COIL WASH WATER TEMPERATURE GLYCOL TEMPERATURE IN -7o C (16o F) GLYCOL COOLING SYSTEM not included GLYCOL CONTROL VALVE not included TEMPERATURE SENSOR PT100 not included PRODUCT TEMPERATURE IN max. 4o C (38o F) REFRESHMENT max. 4o C (38o F) WATER TEMPERATURE AMBIENT TEMPERATURE max. 4o C (38o F) GLYCOL CONTROLS not included 10) Swan neck on dewatering belt 15) Dewatering vibrator instead of dewatering belt The dewatering belt of the washer goes down into the water of f.e. a next washer or water flume. Product that does not automatically...

Basic execution of JBT FTNON swirl bath wash line (2 washers) • Fresh water spraying pipe, 1x • Dewatering belt, 2x • Swan neck on 1st dewatering belt, 1x • Ventilator with air knife in 2nd dewatering belt, 1x • Static filter, 2x In this Swirl Bath Washer Line, 2 Swirl Bath Washers are placed behind each other. JBT FTNON can change the execution if this does not impact the functionality of the equipment. All mentioned sizes, capacities and figures are indicative. No rights may be derived from the information provided. JBT FTNON delivers tailor-made machines. Therefore capacity and dimensions...