GRT8100
1 / 214ページ

カタログの抜粋

Grove GRT8100 Operator Manual

£k WARNING California Proposition 65 Breathing diesel engine exhaust exposes you to chemicals known to the State of California to cause cancer and birth defects or other reproductive harm. • Always start and operate the engine in a well-ventilated area. • If in an enclosed area, vent the exhaust to the outside. • Do not modify or tamper with the exhaust system. • Do not idle the engine except as necessary. For more information, go to www.P65warnings.ca.gov/diesel Batteries, battery posts, terminals, and related accessories can expose you to chemicals, including lead and lead compounds,...

カタログの2ページ目を開く

1 OPERATOR MANUAL This manual has been prepared for and is considered part of - GRT8100 Crane Model Number This Manual is divided into the following sections: SECTION 1 SECTION 2 SECTION 3 SECTION 4 SECTION 5 INTRODUCTION SAFETY INFORMATION OPERATING CONTROLS AND PROCEDURES SET-UP AND INSTALLATION MAINTENANCE AND LUBRICATION 3 NOTICE The crane serial number is the only method your distributor or the factory has of providing you with correct parts and service information. The crane serial number is identified on the builder’s decal attached to the operator cab. Always furnish crane serial...

カタログの3ページ目を開く

THIS PAGE BLANK

カタログの4ページ目を開く

TABLE OF CONTENTS SECTION 1 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . Introduction General . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1-1 Customer Support. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1-1 Noise/vibration Test results . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1-1 Noise Level Test Results . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . ....

カタログの5ページ目を開く

TABLE OF CONTENTS Electrical Contact. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . Special Operating Conditions and Equipment . . . . . . . . . . . . . . . . . . . . . . . . . . . . Grounding the Crane . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . Personnel Handling . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . Environmental Protection . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . ....

カタログの6ページ目を開く

TABLE OF CONTENTS Cab Circulating Fan . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3-5 Right Side Window Latch . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3-5 Overhead Control Panel . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3-6 Skylight Wiper Switch . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3-6 Heater/Air Conditioner Fan Speed Switch . . . . . . . . . . . . . . . . . . . . . . . . . . . . ....

カタログの7ページ目を開く

TABLE OF CONTENTS Limit Bypass Switch (Non-CE Certified Cranes) . . . . . . . . . . . . . . . . . . . . . . . . . . Limit Bypass Switch and Indicator (CE Certified Cranes) . . . . . . . . . . . . . . . . . . . RCL Internal Light Bar (Optional) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . Strobe Light or Beacon (Optional) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . Backup Alarm (Not Shown) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . Emergency Exit . . . . . . . . . . . . . . . . . . . . . . . ....

カタログの8ページ目を開く

TABLE OF CONTENTS Unlocking . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-4 Checking Before Operation. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-4 Hoist Rope Reeving. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-5 Reeving the Hoist Rope Over the Boom. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-6 Dead-End Rigging/Wedge Sockets . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . ....

カタログの9ページ目を開く

TABLE OF CONTENTS Rust Protection . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . Cleaning Procedures . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . Inspection and Repair . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . Application . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . Areas of Application. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . ....

カタログの10ページ目を開く

SECTION CONTENTS Transmission . . . . . . . . . . . . . . . . . . . . . . . . . . . . . Engine . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . Axles . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . Brakes . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . Wheels and Tires. . . . . . . . . . . . . . . . . . . . . . . . . . Swing Gearbox . . . . . . . . . . . . . . . . . . . . . . . . . . . Boom . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . Swivel Assembly . . . . . . . . . . . . . . . . . . . . . . . . . ....

カタログの11ページ目を開く

INTRODUCTION GRT8100 OPERATOR MANUAL crane operator position as measured by Annex G.1 of EN 13000:2010+A1:2014. Vibration Level Test Results • At the operator station with closed cab operation, vibration levels are less than 0.5 m/s/s for Whole Body Vibration exposure and are less than 2.5 m/s/s for Hand Arm Vibration exposure when measured according to 89/392/EEC Community Legislation on Machinery per standard ISO 2631/1 - Evaluation of Human Exposure to Work Body Vibration, ISO 5349 - Guidelines for the Measurement and Assessment of Human Exposure to Hand Transmitted Vibrations, and...

カタログの12ページ目を開く