Group: SMC
Catalog excerpts
201-SJ.qxd 10.5.28 2:02 PM Page 1 4 Port Solenoid Valve Series SJ2000/3000 Cassette Type Manifold Rubber Seal ® 10 00 (SJ3 7. 5 mm ) 000 (SJ2 mm 0) SJ SY 00 J3000 S 0 d SJ2mounte e SV SYJ SZ b r. Can ogethe t VP4 er neciton Con ect conn S0700 VQ VQ4 VQ5 VQC VQZ SQ ø6 VFS ø4 ø2 40 mm Non plug-in type Individual wiring manifold ø2 VFR VQ7 One-touch fitting connection is possible. Vacuum release valve with restrictor Suction and release can be controlled with a single unit. 11
Open the catalog to page 1Power consumption 0.15 W (SJ3000 with power saving circuit) 0.23 W (SJ2000 with power saving circuit) Manifold uses halogen-free lead wires. Service life of 50 million cycles or more (Based on SMC life test conditions) Connector type (Card edge type) • Can easily increase or decrease stations and replace valves. • 34 pins connector allows up to 16 stations with double solenoids, 32 stations with single solenoids. D-sub connector Piping variations With one-touch fittings Threaded type Fittings (including type and size) can be easily changed by removing a clip. With switch • Possible to shut...
Open the catalog to page 24 Port Solenoid Valve Cassette Type Manifold Serial transmission system Flat ribbon cable Serial transmission system EX180 Integrated type (for output) Serial transmission system ■ CC-Link(32 outputs), DeviceNet (32,16 outputs) ■ Easy attaching/detaching of the SI unit and • Separated valve power unit and transmission power unit / Ensuring • Selectable between T-branch and straight type of communication Valve power unit EX510 Gateway system Serial transmission system ■ Max. 128 points (Input 64 points/Output 64 points) ■ All wires can be plugged into the connector units. ■ CC-Link,...
Open the catalog to page 3P0011-P0100-E.qxd 08.9.1 1:53 PM Page 14 4 Position Dual 3 Port Valve B side A side 4(A) • Integrated to a single valve from 3-port valve • Possible to control 4(A), 2(B) port individually. • Can be mounted on the same manifold with a 4-port valve. • Prepared 3 types of combination • Label with the same colors of the manual override is attached to show the functions of A side and B side. N.C. valve N.C. valve 2(B) SOL.b SOL.a 5(EA) A side coil 2(B) 5(EA) 1(P) 3(EB) 2(B) 4(A) SOL.b SOL.a 5(EA) Regulator Block A side passage symbol: Blue SOL.b SOL.a N.C. valve N.O. valve A side manual: Blue...
Open the catalog to page 4275-SJ.qxd 10.7.16 11:39 AM Page 1 ® Vacuum Release Valve with Restrictor Two spool valves are built-in. Vacuum suction and release can be controlled with a single valve. Manual Restrictor Slotted locking type • Flow rate adjustment of release air • Prevents workpiece blow-off. Plug-in Connector connection PS port: Pressure detection port (M5 x 0.8) SJ SY Filter • Eliminates foreign matter on vacuum and release side. • Replaceable SV SYJ SZ 2(B) Vacuum pad port VP4 S0700 1(P) Release pressure port Wiring variations • D-sub connector • Flat ribbon cable • PC wiring VQ 3/5(E) Vacuum pressure...
Open the catalog to page 54 Port Solenoid Valve Series SJ2000/3000 Plug-in Connector Type Manifold D-sub Connector / Flat Ribbon Cable / PC Wiring PC Wiring System with Power Supply Terminal EX180 Integrated Type (for Output) Serial Transmission System EX510 Gateway System Serial Transmission System Non-plug-in Individual Wiring Manifold Individual Wiring Manifold Exploded View Vacuum Release Valve with Restrictor Series SJ3A6 Common Specifications Plug-in Connector Type Manifold D-sub Connector / Flat Ribbon Cable / PC Wiring / Non-plug-in Individual Wiring Manifold Specific Product Precautions Individual Wiring...
Open the catalog to page 64 Port Solenoid Valve Common Specifications Manifold Specifications Note 1 ) When many valves are operated simultaneously, use B type (SUP/EXH both sides), applying pressure to the 1 (P) ports on both sides and exhaust from the 3/5(E) ports on both sides. Note 2) The mass W is the value for the D-sub connector manifold only with internal pilot, SUP/EXH block straight fittings specifications. To obtain the mass with solenoid valves at- tached, add the solenoid valve weights given on page 19 for the appropriate number of stations. Refer to page 77 for the mass of DIN rail. (Please contact SMC...
Open the catalog to page 7EX180 Integrated type (for output) Serial transmission system Serial transmission system Individual wiring Solenoid Valve Specifications Note) Impact resistance: No malfunction occurred when it is tested with a drop tester in the axial direction and at the right angles to the main valve and armature in both energized and de-energized states every once for each condition. (Value in the initial state) Vibration resistance: No malfunction occurred in one sweep test between 45 and 2000Hz. Test was per- formed to axis and right angle directions of the main valve when pilot signal is ON and OFF....
Open the catalog to page 84 Port Solenoid Valve Series SJ2000/3000 Valve model Closed center Exhaust center Pressure center Dual 3 port valve Closed center Exhaust center Pressure center Dual 3 port valve Closed center Exhaust center Pressure center Dual 3 port valve Port size Note) Please contact SMC for the mass of elbow fittings. Connector Wiring Diagram Note) Please contact SMC for the mass of elbow fittings Single solenoid and double solenoid Connector side Double solenoid Single solenoid Double solenoid Station 3 Station 2 Station 1 Single solenoid with double wiring spec. Connector side Unused terminal -...
Open the catalog to page 92 position single with back pressure check valve 2 position double with back pressure check valve 3 position closed center 3 position pressure center Component Parts 3 position exhaust center Replacement Parts 3 position closed center/exhaust center/pressure center SJ2260K with back pressure check valve
Open the catalog to page 104 Port Solenoid Valve Series SJ2000/3000 4 position dual 3 port valve SJ2A60K with back pressure check valve SOL.a SOL.b^^ SJ2B60K with back pressure check valve SOL.a SOL.b SJ2C60K with back pressure check valve SJ2C60 [N.C. valve, N.O. valve x 1 (each)] Component Parts Spool valve assembly Spool valve assembly Adaptor plate Pilot adaptor Pilot valve assembly Body cover Port block Bottom cover Light cover Zinc die-cast Light blue Replacement Parts One-touch fitting Refer to the one-touch fitting part no. SJ2A60K with back pressure check valve
Open the catalog to page 11All SMC PNEUMATIC catalogs and technical brochures
-
SYJ300/500/700 Series
62 Pages
-
Vacuum Unit ZK2 Series
60 Pages
-
Air Cylinder CJ2 Series
117 Pages
-
AS-FS Series
36 Pages
-
IDF series
12 Pages
-
MHL2 Series
24 Pages
-
JCM Serie
18 Pages
-
EX245 Series
12 Pages
-
Pin Cylinder CJP2/CDJP2/CJP
19 Pages
-
5 Port Solenoid Valve VQC
63 Pages
-
5 Port Solenoid Valve VQ
79 Pages
-
SY
268 Pages
-
5-p0979-0980-hep500
2 Pages
-
5-p0977-0978-aep100
2 Pages
-
5-p0966-0971-lmu
5 Pages
-
5-p0960-0966-alb900
6 Pages
-
5-p0956-0960-ald600
5 Pages
-
5-p0948-0950-al800
3 Pages
-
es70-44c-vx2
52 Pages
-
es50-37-kq2
124 Pages
-
ex-pcw
23 Pages
-
1-p2124-2152-ex510
29 Pages
-
1-p2111-2122-ex500
12 Pages
-
1-p2063-2073-ex260
11 Pages
-
4-p0147-0178-msu-mds
32 Pages
-
es20-230b-crb2
59 Pages
-
1-p1869-1878-vp3145
10 Pages
-
VP300/500/700 series
42 Pages
-
1-p1789-1829-vqz100
41 Pages
-
1-p1727-1788-syj300
62 Pages
-
5 Port Solenoid Valve S0700
111 Pages
-
5 Port Solenoid Valve VF
59 Pages
-
5 Port Solenoid Valve SV
127 Pages
-
VH
9 Pages
-
CUJ
41 Pages
-
AL
3 Pages
-
kj mm
9 Pages
-
AQ
4 Pages
-
SY3000/5000-X13
2 Pages
-
Series MB
24 Pages
-
Series LES
23 Pages
-
Series LEFB
16 Pages
-
Series PF3W
28 Pages
-
Series IDG?A/IDG
56 Pages
-
Floating Joint
7 Pages
-
Series IZS40/41/42
32 Pages
-
Series LEY
7 Pages
-
Series VHS
12 Pages
-
Series CY1S
28 Pages
-
SeriesCQ2/CQS/CQ
4 Pages
-
In-line Air Filter
12 Pages
-
5 Port Solenoid Valve
60 Pages
-
Series CQ2/CQS
2 Pages
-
AS series
2 Pages
-
corporate guide
13 Pages
-
ZP
69 Pages
-
ZFA
14 Pages
-
ZA
13 Pages
-
MHF
32 Pages
-
MHZ
68 Pages
-
CRB
44 Pages
-
D
117 Pages
-
RB
23 Pages
-
CEP
44 Pages
-
RSK
30 Pages
-
CLK
51 Pages
-
MK
20 Pages
-
GLJ
65 Pages
-
MGJ
7 Pages
-
Mx
36 Pages
-
MXH
18 Pages
-
My3
56 Pages
-
my1b
20 Pages
-
CC
15 Pages
-
J
14 Pages
-
CQ2
51 Pages
-
standard cylinder
84 Pages
-
VFN
6 Pages
-
SY3000
246 Pages
-
SJ3A6
18 Pages
-
1301/IW
14 Pages
-
CHQ/CHDQ
19 Pages
-
AC
95 Pages
-
HAW
4 Pages
-
HAA
3 Pages
-
ZB
24 Pages
-
CRB2
35 Pages
-
CJ1
5 Pages
-
SYJ
62 Pages