video corpo

Shuttlelift CD5520 - 16 Pages

  1. P. 1

  2. P. 2

  3. P. 3

  4. P. 4

  5. P. 5

  6. P. 6

  7. P. 7

  8. P. 8

  9. P. 9

  10. P. 10

Catalogue excerpts

Grove Manitowoc National Crane Potain Product Guide 16,6 m (54.5 ft) four-section, four-plate full power boom • 9,071 (10 USt) deck carrying capacity • Exclusive pivoting boom nose

 Open the catalogue to page 1

The CD5520 comes standard with three steering modes: front (two-wheel), four-wheel coordinated, and four-wheel crab steer with electronic self alignment. Operators can choose between modes using a three-position rocker switch located on dash panel. The reach and capacity to get the job done The 5,64 m - 16,61 m (18.5 ft - 54.5 ft) four-section boom can be enhanced with optional boom extensions. The 4,6 m (15 ft) fixed swingaway extension offers a maximum tip height of 23,1 m (76 ft) while the 4,6 m - 7,6 m (15 ft - 25 ft) telescopic extension provides a maximum tip height of 26,2 m (86 ft). Both...

 Open the catalogue to page 2

Specifications Superstructure *Load Moment Indicator Boom 5,64 m – 16,61 m (18.5 ft – 54.5 ft) four-section full power boom. Maximum tip height: 19,2 m (63 ft) *Optional boom extensions “Graphics Display” of boom angle, boom length, load radius, and capacity. Operator input to set the limit parameters based on the load chart. Displays color coded light bar and audible alarm with function cut-out if load exceeds the load chart parameters. 4,6 m (15 ft) fixed swingaway extension. Maximum tip height: 23,1 m (76 ft) 4,6 m – 7,6 m (15 ft – 25 ft) telescopic swingaway extension. Maximum tip height:...

 Open the catalogue to page 4

Specifications Carrier Fuel tank capacity Chassis High strength alloy frame constructed with integral outrigger housings; front and rear lifting, tie-down, and towing lugs. 66.3 sq. ft. carrydeck size with 9072 kg (20,000 lb) deck only carrying capacity. Deck coated with anti-skid treatment. Outriggers Single stage hydraulic telescoping beam with oblique style jack cylinder on all four corners. Provides extended and down and retracted and down lifting capabilities. Integral holding valve on both beam and jack. Outrigger positioning indicator located in dash display. Outrigger pad size: 222 mm...

 Open the catalogue to page 5

Specifications Carrier continued Gradeability (theoretical) Steer Standard three steering modes. Front (two-wheel), four-wheel coordinated, and four-wheel crab steer with electronic self alignment. Three position rocker switch located on dash panel. Outside Turning Radius: Two wheel steer: 6,2 m (20 ft 4.8 in) Four wheel steer: 3,9 m (13 ft 1 in) Miscellaneous standard equipment Suspension/axles Front: Drive / steer in both two-wheel drive and four-wheel drive Rear: non-drive with steer in two-wheel drive, drive/ steer in four-wheel drive. Front axle is rigid mounted to frame. Rear axle offers...

 Open the catalogue to page 6

Two-wheel steer Four-wheel steer Radius B Radius C Radius A

 Open the catalogue to page 7

Crane weight Basic machine: Including 16,6 m (54.5 ft) main boom, main hoist with 97,5 m (320 ft) of wire rope, 18 t (20 USt) hook block, full counterweight, Tier IV engine Crane weight Basic machine: Including 16,6 m (54.5 ft) main boom, main hoist with 97,5 m (320 ft) of wire rope, 18 t (20 USt) hook block, full counterweight, Tier IV engine Add: 4,6 m - 7,6 m (15 ft - 25 ft) telescopic swingaway extension and extension carrier brackets and downhaul weight Basic machine: Including 16,6 m (54.5 ft) main boom, main hoist with 97,5 m (320 ft) of wire rope, 18 t (20 USt) hook block, full counterweight,...

 Open the catalogue to page 8

Height from the ground in feet Operating radius in feet from axis of rotation THIS CHART IS ONLY A GUIDE AND SHOULD NOT BE USED TO OPERATE THE CRANE. The individual crane’s load chart, operating instructions and other instructional plates must be read and understood prior to operating the crane.

 Open the catalogue to page 9

Load chart MAIN BOOM LOAD RATINGS ON OUTRIGGERS MAIN BOOM LOAD RATINGS ON OUTRIGGERS Retracted and Down 360˚ 1) The rated loads are the maximum lift capacities as determined by operating radius, boom length and boom angle. The operating radius is the horizontal distance from a projection of the axis of rotation to the supporting surface, before loading, to the center of vertical hoist line or tackle with load applied. 2) The rated loads shown on outriggers do not exceed 85% of actual tipping. The rated loads shown on rubber do not exceed 75% of actual tipping. These ratings are based on freely...

 Open the catalogue to page 10

Load chart 1 5 FT JIB CAPACITIES ON EXTENDED OUTRIGGERS MAIN BOOM ON RUBBER Main Boom Angle (deg) To 42.5 ft To 54.5 ft To 42.5 ft To 54.5 ft Main Main Main Main Boom Boom Boom Boom To 42.5 ft To 54.5 ft To 42.5 ft To 54.5 ft Main Main Main Main Boom Boom Boom Boom NOTES: JIB CAPACITY IS LIMITED BY BOTH STRUCTURAL CAPACITY CHART AND MAIN CAPACITY CHART. SHADED AREAS ARE GOVERNED BY STRUCTURAL STRENGTH, DO NOT RELY ON TIPPING. OPERATION OF THIS EQUIPMENT IN EXCESS OF RATING CHARTS AND DISREGARD OF INSTRUCTIONS IS DANGEROUS AND VOIDS WARRANTY. SIDE 15° 1) The rated loads are the maximum lift capacities...

 Open the catalogue to page 11

PIVOT HOLE PATTERN RIGGING CHART 1 -PART 0-10,000 lb WIRE ROPE: 9/16" Diameter 6 X 19 Bright Minimum required breaking strength = 37,000 lb MAXIMUM PERMISSIBLE SINGLE LINE PULL = 10,000 lb LOW HEADROOM OPERATION (45° MAX. BOOM ANGLE; SINGLE PART LINE ONLY) LOW HEADROOM OPERATION (55° MAX. BOOM ANGLE) STANDARD HEADROOM OPERATION (80° MAX. BOOM ANGLE) NO OFFSET J IB OPERATION (75° MAX. BOOM ANGLE) OFFSET J IB OPERATION (80° MAX. BOOM ANGLE) G7 LOAD DISTRIBUTION CHART Maximum Allowable Uniformly Distributed Load AREA 1 2 4,01 m (43.2 sq.ft.) 1. Maximum travel speed with any or all loads - 4,0 km/h...

 Open the catalogue to page 12

Symbols glossary Axles Boom elevation Boom extension Boom length Boom nose Electrical system Hydraulic system Fuel tank capacity Outrigger controls

 Open the catalogue to page 13

Manitowoc Cranes Regional headquarters Americas Manitowoc, Wisconsin, USA Tel: +1 920 684 6621 Fax: +1 920 683 6277 Regional offices Americas Brazil Alphaville Mexico Monterrey Chile Santiago Europe, Middle East, Africa Czech Republic Netvorice France Baudemont Cergy Decines Germany Langenfeld Hungary Budapest Italy Lainate Netherlands Breda Poland Warsaw Portugal Baltar Russia Moscow South Africa Johannesburg U.A.E. Dubai U.K. Buckingham ©2013 Manitowoc Form No. CD5520 PG Part No. 13-004 /2M /0113 China Beijing Chengdu Guangzhou Xian Greater Asia-Pacific Australia Brisbane Melbourne Sydney India...

 Open the catalogue to page 16

All Manitowoc Cranes catalogues and technical brochures

  1. GHC55

    2 Pages

    En
  2. GHC50

    2 Pages

    En
  3. GRT8100

    2 Pages

    En
  4. GMK5180-1

    40 Pages

    En
  5. GMK5250L

    2 Pages

    En
  6. GMK5200-1

    2 Pages

    En
  7. Igo 13

    4 Pages

    En
  8. Potain Igo 15

    4 Pages

    En
  9. Igo 18

    4 Pages

    En
  10. Potain Igo 21

    4 Pages

    En
  11. Potain Range

    2 Pages

    En
  12. MR 615 H32

    8 Pages

    En
  13. 2250 MAX-ER

    104 Pages

    En
  14. 21000 MAX-ER

    44 Pages

    En
  15. 18000 MAX-ER

    64 Pages

    En
  16. 500E2

    16 Pages

    En
  17. NBT15 Series

    16 Pages

    En
  18. 400B

    16 Pages

    En
  19. 12000-1

    24 Pages

    En
  20. 11000-1

    24 Pages

    En
  21. 10000B-1

    24 Pages

    En
  22. 10000A-1

    24 Pages

    En
  23. 8500-1

    24 Pages

    En
  24. 8000-1

    24 Pages

    En
  25. KMK5175

    12 Pages

    En
  26. KMK5150

    11 Pages

    En
  27. KMK5130

    10 Pages

    En
  28. KMK4085

    12 Pages

    En
  29. KMK4080

    12 Pages

    En
  30. KMK3045

    9 Pages

    En
  31. RT9150E

    32 Pages

    En
  32. RT9130E-2

    28 Pages

    En
  33. RT890E

    28 Pages

    En
  34. RT600E

    16 Pages

    En
  35. GMK4115L

    24 Pages

    En
  36. RT880E

    28 Pages

    En
  37. RT770E

    28 Pages

    En
  38. RT765E-2

    28 Pages

    En
  39. RT540E

    24 Pages

    En
  40. RT550E

    24 Pages

    En
  41. RT530E-2

    24 Pages

    En
  42. TMS800E

    64 Pages

    En
  43. TMS9000E

    36 Pages

    En
  44. GMK5220

    36 Pages

    En
  45. TMC540

    20 Pages

    En
  46. GMK5170

    36 Pages

    En
  47. GMK5130-2

    32 Pages

    En
  48. GMK5110-1

    36 Pages

    En
  49. GMK4100

    32 Pages

    En
  50. GMK5095

    36 Pages

    En
  51. GMK4100L

    36 Pages

    En
  52. GMK3050-1

    24 Pages

    En
  53. GMK4080-1

    28 Pages

    En
  54. GMK2035E

    22 Pages

    En
  55. Igo range

    16 Pages

    En
  56. MCT Tower Cranes

    4 Pages

    En
  57. MD Tower Cranes

    12 Pages

    En
  58. MR Tower Cranes

    4 Pages

    En
  59. Shuttlelift CD7725

    16 Pages

    En
  60. Grove GMK3060

    32 Pages

    En
  61. Grove TMS700E

    34 Pages

    En
  62. Grove GMK6300L

    40 Pages

    En
  63. Grove GMK6400

    100 Pages

    En
  64. Grove GMK5115

    24 Pages

    En
  65. Grove GMK5225

    28 Pages

    En
  66. Grove GMK5165-2

    20 Pages

    En
  67. Grove GMK5275

    24 Pages

    En
  68. GMK4100B

    20 Pages

    En
  69. Grove GMK4115

    32 Pages

    En
  70. Grove GMK7550

    60 Pages

    En
  71. Grove GMK5135

    20 Pages

    En
  72. Grove TMS700E

    40 Pages

    En
  73. Grove GMK3055

    28 Pages

    En
  74. GTK1100

    36 Pages

    En
  75. Igo 10/Igo 11

    2 Pages

    En

Archived catalogues

  1. Crawler Cranes

    28 Pages

    En